Sigtronics RES-601 Installation Instructions User Manual download pdf

ST-400 / ST-600 STEREOCOM Installation Instructions

Specialists in “SOUND” Management

178 East Arrow Highway, San Dimas, CA 91773 ( 909 ) 305-9399

INTRODUCTION

ATTENTION INSTALLER: To assure a trouble free

installation, please read the entire instructions through

once before beginning.

CONFIGURATION - Sigtronics Stereocom systems are

specically designed for permanent, panel mounted

installation in aircraft. They are congured in two sections:

a SPA-400 (4 place) or SPA-600 (6 place) intercom with

transmit capability, and a RES-401 or RES-601 Stereo Music

Switcher. Both intercom and switcher may be installed at the

same time, or the switcher section may be easily added to

an existing SPA intercom installation.

MUSIC INPUTS - The Stereocom music inputs are fully

compatible with music systems that have line level output,

headphone level (Walkman) output, or speaker output up to

25 watts per channel. No ampliers, adapters or modications

to the RES unit are required.

SIZE SPA UNIT - Panel 1” x 2.5”. Chassis - 1” high x 2.5” wide

x 6” deep. Can be mounted either horizontally or vertically

in the aircraft panel.

SIZE RES UNIT - A 4” x 2.9” x 2” chassis mounted

remotely.

WEIGHT SPA UNIT - 4.5 ounces (SPA-400 intercom unit

with panel and knobs). Jacks and wiring harness weigh 5.5

ounces.

RES UNIT: 9.8 oz. (RES-401). Harnesses - 5.2 oz.

INPUT POWER - 11VDC through 32VDC. Maximum current

drain 0.13 Amp (ST-400).

DISTORTION - Less than 1% total harmonic distortion.

ENVIRONMENTAL - Meets requirements of TSO-C50b.

WARRANTY - The ST units are constructed of high quality

components and carry a ve year parts and labor warranty.

INSTALLATION FOR COMPLETE

ST-400 / ST-600 SYSTEM

If a RES-401 or RES-601 is to be added to an existing SPA

installation, proceed to the “Installation Retrot” on page 3.

Hardware Supplied

Besides the intercom and music switcher unit, each

Stereocom system comes with the following hardware:

ST-400 ST-600

Headphone Output Jacks - Accept standard

0.250” aircraft stereo headphone plugs. 4 6

Microphone Input Jacks - Accept standard

0.206” aircraft microphone plugs. (U93 plug

compatible jacks can be used in place of the

jacks provided - mono installations only). 4 6

Mic Jack Insulating Washers, Flat 4 6

Mic Jack Insulating Washers, Shoulder 4 6

SPA Panel - lettered on both sides for

horizontal or vertical mounting. 1 1

Intercom/Aircraft Interface Cable (4 feet long) 1 1

Intercom Control Knobs 2 2

Switch Nuts 3 3

SPA Mounting Screws 4-40 x 1/2 2 2

SPA Drill Template - Adhesive backed hole

size pattern for drilling aircraft panel. 1 1

Music Input / Interface Cable (4 feet long) 1 1

Music Switch Harness (4 feet long) 1 1

Music Switch Panel 1 1

Stereo Music Input Jack - 3.5mm 1 1

RES Mounting Screws 4 4

RES Mounting Nuts 4 4

SPA-400 / 600 CHASSIS INSTALLATION

The location selected requires a minimum front panel area

of 2 1/2” by 1”. Depth required behind panel is 4” plus cable

access. Allow approximately 1” by 1 1/2” space nearby to

mount the music switch panel.

CAUTION: Move aircraft ight controls through limits

of travel while observing selected area to make certain

intercom components will not interfere with aircraft control

components.

1 2 3 4 5 6

Summary of Contents

Page 1 - ST-400 / ST-600 SYSTEM

ST-400 / ST-600 STEREOCOM Installation InstructionsSpecialists in “SOUND” Management178 East Arrow Highway, San Dimas, CA 91773 ( 909 )

Page 2 - AIRCRAFT

                                                      AIRCRAFTPANELFigure 1

Page 3 -  

          

Page 4

 Figure 4page 410. A Sigtronics Stereo-com system can be installed for use with monaural ge

Page 5

End of Jumper to Move Move to this PadFigure 5Mode Selection TablePILOT/ ALL SWITCHMUSIC SWITCHPILOT & CO-PILOT HEARPASSENGERS HEARAll Off VHF and

Page 6 - Sigtronics Corporation

page 61-17-2007 st400ins.pdfSigtronics Corporation178 East Arrow HighwaySan Dimas, CA 91773Phone: (909) 305-9399E-mail: [email protected] Sit

Comments to this Manuals

No comments

Sigtronics RES-601 Installation Instructions User Manual

Browse online or download User Manual for Accessories communication Sigtronics RES-601 Installation Instructions. Sigtronics RES-601 Installation Instructions User Manual

Summary of Contents

Comments to this Manuals

Related products and manuals for Accessories communication Sigtronics RES-601 Installation Instructions